Bio-oil Production from Napier Grass Using a Pyrolysis Process: Comparison of Energy Conversion and Production Cost between Bio-oil and Other Biofuels

Wasakorn Treedet, Ratchaphon Suntivarakorn, Ilham Mufandi, Piyapong Singbua

Abstract


This article presents bio-oil production from Napier grass by using a pyrolysis process. The comparative potential of energy conversion and the cost of production among bio-oil, bio-ethanol, biogas and syngas from gasification by using Napier grass as raw material were also analyzed. The pyrolysis in this study was developed from previous work in order to improve the yield of bio-oils. The circulating fluidized bed reactor (CFBr) was used as the reactor, and a new scrub condenser was applied in order to increase the performance of condensing vapor into bio-oil. This system had the ability to feed Napier grass between 45-75 kg/hr, and it could create a solid-recirculating rate of about 52.36 kg/m2s at 7 m/s of maximum superficial velocity. From the results of the bio-oil production, it has been concluded that the maximum yield of bio-oil production is 44.60 wt% at a feed rate of 60 kg/hr and bed temperature of 480°C. The properties and chemical components of bio-oil were also determined. A comparison of energy conversion from Napier grass to products such as bio-oil, ethanol, biogas and syngas through the gasification process as well as an analysis of cost of production revealed that syngas production through gasification has a greater potential energy conversion and cost of production than other technology, which had an energy conversion efficiency and cost of production of about 72.65% and 0.26 USD/GJ, respectively. However, as compared to liquid fuel, the gas fuel has greater limitations in terms of utilization and transportation. The bio-oil production from pyrolysis in this study had a cold efficiency and cost of production of about 28.24% and 17.98 USD/GJ, which proved a more advantageous trend of cold efficiency and production cost than bio-ethanol production, thus it can support a large energy project to create more energy security.

Keywords


bio-oil; CFBr; energy conversion; Napier grass; production cost.

Full Text:

PDF

References


Ministry of Energy, 2017. Energy balance of Thailand 2017. Report, Retrieved November 12, 2018 from the World Wide Web: https://www.dede.go.th/download/state_61/Energy%20Balance%20of%20Thailand%202017.pdf.

Electricity generating authority of Thailand, 2017. Fraction of energy consume for electric production of EGAT 2017. Graph and statistics, Retrieved November 14, 2018 from the World Wide Web: https://www.egat.co.th/index.php?option=com_content&view=article&id=2455&Itemid=116.

Energy policy and planning office of Thailand, 2015. Alternative Energy Development Plan 2015 – 2036. Policy and plan, Retrieved March 10, 2018 from the World Wide Web: http://www.eppo.go.th/index.php/en/policy-and-plan/en-tieb/tieb-aedp.

Pincam T., Brix H., Eller F. and Jampeetong A., 2017. Hybrid Napier grass as a candidate species for bio-energy in plant-based water treatment systems: Interactive effects of nitrogen and water depth. Aquatic Botany 138: 82-91.

Haegele T. and W. Arjharn. 2017. The effects of cultivation methods and planting season on biomass yield of Napier grass (Pennisetum purpureum Schumach.) under rainfed conditions in the northeast region of Thailand. Field Crops Research 214: 359-364.

Waramit N. and J. Chaugool. 2014. Napier grass: A novel energy crop development and the current status in Thailand. Journal of international society of Southeast Asian agricultural Sciences 20: 139–150.

Divyabbharathi R. and R. Venkatachalam. 2015. Energy conversion study on cumbu napier CO-4. International Journal of Agriculture, Environment, and Biotechnology 8: 727-733.

Rocha J.R.A.S.C., Machado J.C., Carneiro P.C.S., Carneiro J.C., Resende M.D.V., Pereira A.V., and Carneiro J.E.S., 2017. Elephant grass ecotypes for bioenergy production via direct combustion of biomass. Industrial Crops and Products 95: 27-32.

Department of energy of United State/EIA, 2017. Monthly energy review. December 2017, Retrieved December 1, 2017 from the World Wide Web: https://www.eia.gov/totalenergy/data/monthly/pdf/mer.pdf/.

Brammer JG., Lauer M. and Bridgewater AV., 2006. Opportunities for biomass-derived “bio-oil” in European heat and power markets. Energy Policy 34: 2871-2880.

Energy policy and planning office, Ministry of energy of Thailand, 2016. Alternative energy development plan. Policy and Plan, Retrieved May 15, 2016 from the World Wide Web: http://www.eppo.go.th/index.php/en/policy-and-plan/en-tieb/tieb-aedp/.

Heryadi H.D. and D. Hartono. 2016. Energy efficiency, Utilization of renewable energies, and carbon dioxide emission: Case study of G20 countries. International Energy Journal 16: 143-152.

Ezeji T.C., Qureshi N. and Blaschek H.P., 2007. Bioproduction of butanol from biomass: from genes to bioreactors. Current Opinion in Biotechnology 18: 220-227.

Liu Y.K., Chen W.C., Huang Y.C., Chang Y.K., Chu I.M., Tsai S.L. and Wei Y.H., 2017. Production of bioethanol from Napier grass via simultaneous saccharification and co-fermentation in a modified bioreactor. Journal of Bioscience and Bioengineering 124: 184-188.

Yasuda M., Takeo K., Nagai H., Uto T., Yui T., Matsumoto T., Ishii Y. and Ohta K., 2013. Enhancement of ethanol production from Napier grass (Pennisetum purpureum Schumach) by a low-moisture anhydrous ammonia pretreatment. Journal of Sustainable Bioenergy Systems 3: 179-185.

Eliana C., Jorge R., Juan P. and Luis R., 2014. Effect of the pretreatment method on enzymatic hydrolysis and ethanol fermentability of the cellulosic fraction from elephant grass. Fuel 118: 41-47.

Menegol D., Fontana R.C., Dillon A.J.P. and Camassola M., 2016. Second-generation ethanol production from elephant grass at high total solids. Bioresource Technology 211: 280-290.

Santos C.C., Souza W.D., Anna C.S. and Brienzo M. 2018. Elephant grass leaves have lower to recalcitrance to acid pretreatment than stems, with potential for ethanol production. Industrial Crops and Products 111: 193-200.

Ko C.H., Yu F.C., Chang F.C., Yang B.Y., Chen, W.H., Hwang W.S. and Tu T.C., 2017. Bioethanol production from recovered napier grass with heavy metals. Journal of Environmental Management 203: 1005-1010.

Pensri B., Aggarangsri P., Chaiyaso T. and Chandet N., 2016. Potential of fermentable sugar production from Napier cv. Pakchong 1 grass residue as a substrate to produce bioethanol. Energy Procedia 89: 428-436.

Treedet W. and R. Suntivarakorn. 2016. A comparison of energy conversion between pyrolysis and gasification process for bio-fuel production from sugarcane trash. Journal of Biobased Materials and Bioenergy 6: 622–626.

Mohammed I.Y., Abakr Y.A., Yusup S. and Kazi F.K., 2017. Valorization of Napier grass via intermediate pyrolysis: optimization using response surface methodology and pyrolysis products characterization. Journal of Cleaner Production 142: 1848–1866.

Bridgwater A.V., 2003. Renewable fuels and chemicals by thermal processing of biomass. Chemical Engineering Journal 91: 87-102.

Bridgwater AV. and G.V.C. Peacocke. 2000. Fast pyrolysis processes for biomass. Renewable and Sustainable Energy Reviews 4: 1-73.

Strezov V., Evans T.J. and Hayman C., 2008. Thermal conversion of elephant grass (Pennisetum Purpureum Schum) to bio-gas, bio-oil and charcoal. Bioresource Technology 99: 8394-8399.

Mohammed I.Y., Abkr Y.A., Kazi F.K., Yusuf S., Alshareef I. and Chin S.A., 2015. Pyrolysis of Napier grass in a fixed bed reactor: Effect of operating conditions on product yields and characteristics. Bioresources 10: 2681-2690.

Lee M.K., Tsai W.T., Tsai Y.L. and Lin S.H., 2010. Pyrolysis of Napier grass in an induction heating reactor. Journal of Analytical and Applied Pyrolysis 88: 110–116.

Conto D.D., Silvestre W.P., Baldasso C. and Godinho M., 2016. Performance of rotary kiln reactor for the elephant grass pyrolysis. Bioresource Technology 218: 153-160.

Singbua P., Treedet W., Duangthong P., Seithtanabutara V. and Suntivarakorn R., 2017. Bio-oil production of Napier grass by using rotary cylindrical reactor. Energy Procedia 138: 641-645.

Ferreira S.D., Lazzarotto I.P., Junges J., Manera C., Godinho M. and Osorio E., 2017. Steam gasification of biochar derived from elephant grass pyrolysis in a screw reactor. Energy Conversion and Management 153:163-174.

Suntivarakorn R., Treedet W., Singbua P. and Teeramaetawat N., 2018. Fast pyrolysis from Napier grass for pyrolysis oil production by using circulating fluidized bed reactor: Improvement of pyrolysis system and production cost. Energy Reports 4: 565-575.

Khezri R., Azlina W. and Tan H.B., 2016. An experimental investigation of syngas composition from small-scale biomass gasification. International Journal of Biomass and Renewables 5: 6-13.

Wilawan W., Pholchan P. and Aggarangsi P., 2014. Biogas production from Co-digestion of Pennisetum pururem cv. Pakchong 1 grass and layer chicken manure using completely stirred tank. Energy Procedia 52: 216-222.

Suttijunda S., 2015. Biogas production from hydrolysate Napier grass by co-digestion with slaughterhouse wastewater using anaerobic mixed cultures. KKU Research Journal 20: 323-336.

Divyabharathi R. and P. Venkatachalam. 2015. Energy conversion study on cumbu napier CO-4. International Jjournal of Agriculture, Environment and Biotechnology 8: 727-733.

Carvalho A.R., Fragoso R., Gominho J., Saraiva A., Costa R. and Duarte E., 2016. Water-energy nexus: Anaerobic co-digestion with elephant grass hydrolysate. Journal of Environmental Management 181: 48-53.

Treedet W. and R. Suntivarakorn. 2018. Design and operation of a low cost bio-oil fast pyrolysis from sugarcane bagasse on circulating fluidized bed reactor in a pilot plant. Fuel Processing Technology 179: 17-31.

Wongwatanapaiboon J., Kangvansaichol K., Burapatana V., Inochanon R., Winayanuwattikun P., Yongvanich T. and Chulalaksananukul W., 2012. The potential of cellulosic ethanol production from grasses in Thailand. Journal of Biomedicine and Biotechnology 2012: 1-10.

Yasuda M., Nagai H., Takeo K., Ishii Y. and Ohta K., 2014. Bio-ethanol production through simultaneous saccharification and co-fermentation (SSCF) of a low-moisture anhydrous ammonia (LMAA)-pretreated napiegrass (Pennisetum purpureum Schumach). Springer Plus, Retrieved November 10, 2018 from the World Wide Web: https://www.ncbi.nlm.nih.gov/pmc/articles/PMC4447740/pdf/40064_2014_Article_1551.pdf.

Wellinger A., Murphy J. and Baxter D., 2013. The biogas handbook: science production and application. Oxford: Woodhead publishing limited.

Somsiri S. and S. Vivanpatarakij. 2015. Potentials of transforming Napier grass to energy. Journal of Energy Research 12: 47-58.

Energy Research and Development Institute-Nakornping., 2018. The study of suitable condition to produce biogas from grasses in Thailand. Project proposal, Retrieved November 12, 2018 from the World Wide Web: http://www.erdi.cmu.ac.th/cstr-grasse/#.

Lee S. and Shah,Y.T., 2012. Biofuels and Bioenergy: Process and Technologies. Boca raton: CRC press.

Khezri R., Azlina W. and Tan H.B., 2016. An experimental investigation of syngas composition from small-scale biomass gasification. International Journal of Biomass and Renewables 5: 6-13.

Mei Y., Liu R., Wu W. and Zhang L., 2016. Effect of hot vapor filter temperature on mass yield, energy balance, and properties of products of the fast pyrolysis of pine sawdust. Energy Fuels 30: 10458–10469.

Solantausta Y., Beckman D., Bridgwater A.V., Diebold. J.P. and Elliott, D.C., 1992. Assessment of liquefaction and pyrolysis systems. Biomass Bioenergy 2: 279–297.

Cottam M.L. and A.V. Bridgwater. 1994. Techno-economic modelling of biomass flash pyrolysis and upgrading systems. Biomass Bioenergy 7: 267–273.

Gregoire C.E. and R.L. Bain. 1994. Technoeconomic analysis of the production of biocrude from wood. Biomass Bioenergy 7: 275–283.

Islam M.N. and F.N. Ani. 2000. Techno-economics of rice husk pyrolysis, conversion with catalytic treatment to produce liquid fuel. Bioresource Technology 73: 67–75.

Mullaney H., Farag I.H., LaClaire C.E. and Barrett C.J., 2002. Technical, Environmental and Economic Feasibility of Bio-Oil in New Hampshire’s North Country. Final Report, Retrieved May 13, 2017 from the World Wide Web: https://dokumen.tips/documents/technical-environmental-and-economic-feasibility-of-bio-final-report-technical.html.

Peacocke G.V.C., Bridgwater A.V. and Brammer J.G., 2004. Techno-economic assessment of power production from the Wellman and BTG fast Pyrolysis processes, Retrieved May 16, 2017 from the World Wide Web: http://citeseerx.ist.psu.edu/viewdoc/download?doi=10.1.1.578.9619&rep=rep1&type=pdf.

Marker T., Petri J., Kalnes T., McCall M., Mackowiak D., Jerosky B., Reagan B., Nemeth L. and Krawczyk M., 2005. Opportunities for biorenewables in oil refineries. Technical Report, Retrieved May 16, 2017 from the World Wide Web: https://www.osti.gov/scitech/servlets/purl/861458.

Ringer M., Putsche V. and Scahil J., 2006. Large-scale pyrolysis oil production: A technology assessment and economic analysis. Technical Report, Retrieved May 19, 2017 from the World Wide Web: https://www.nrel.gov/docs/fy07osti/37779.pdf.

Uslu A., Faaij A.P.C. and Bergman P.C.A., 2008. Pre-treatment technologies, and their effect on international bioenergy supply chain logistics. Techno-economic evaluation of torrefaction, fast pyrolysis and pelletisation. Energy 33: 1206-1223.

Velden M.V.D., Baeyens J. and Boukis I., 2008. Modeling CFB biomass pyrolysis reactors. Biomass Bioenergy 32: 128-139.

Dynamotive., 2009. The financial statement of Dynamotive Energy Systems Corporation. Period of Report, Retrieved June 1, 2017 from the World Wide Web: http://pdf.secdatabase.com/2115/0001137171-09-000668.pdf.

Badger P., Badger S., Puettmann M., Steele P. and Cooper J., 2010. Techno-economic analysis: preliminary assessment of pyrolysis oil production costs and material energy balance associated with a transportable fast pyrolysis system. BioResources 6: 34–47.

Czernik S., French R. and Penev M.M., 2010. Distributed bio-oil reforming. Presentation at 2010 annual merit review and peer evaluation meeting, Retrieved June 10, 2017 from the World Wide Web: https://www.nrel.gov/docs/fy10osti/48066.pdf.

Wright M.M., Daugaard D.E., Satrio J.A. and Brown R.C., 2010. Techno-economic analysis of biomass fast pyrolysis to transportation fuels. Fuel 89: 2-10.

Rogers J.G. and J.G. Brammer. 2012. Estimation of the production cost of fast pyrolysis bio-oil. Biomass Bioenergy 36: 208–217.

Jones S.B. and J.L. Male. 2012. Production of gasoline and diesel from biomass via fast pyrolysis, hydrotreating and hydrocracking: A case study. Technical report, Retrieved July 12, 2017 from the World Wide Web: https://www.pnnl.gov/main/publications/external/technical_reports/PNNL-18284.pdf.

Brown D., Rowe A. and Wild P., 2013. A techno-economic analysis of using mobile distributed pyrolysis facilities to deliver a forest residue resource. Bioresource Technology 150: 367–376.

Czernik S. and R. French. 2014. Distributed production of hydrogen by auto-thermal reforming of fast pyrolysis bio-oil. International Journal of Hydrogen Energy 39: 744–750.

Mirkouei A., Mirzaie P., Haapala K.R., Sessions J. and Murthy G.S., 2016. Reducing the cost and environmental impact of integrated fixed and mobile bio-oil refinery supply chains. Journal of Cleaner Production 113: 495-507.

Zhao L., Zhang X., Xu J., Ou X., Chang S. and Wu M., 2015. Techno-economic analysis of bioethanol production from Linocellulosic biomass in china: Dilute-acid pretreatment and enzymatic hydrolysis of Corn Stover. Energies 8: 4096 – 4117.

Humbird D., Davis R., Tao L., Kinchin C., Hsu D., Aden A., Schoen P., Lukas J., Olthof B., Worley M., Sexton D. and Dudgeon D., 2011. Process design and economics for biochemical conversion of Lignocellulosic biomass to Ethanol: Dilute-acid pretreatment and enzymatic hydrolysis of Corn Stover. Technical report, Retrieved March 31, 2019 from the world Wide Web: https://www.nrel.gov/docs/fy11osti/47764.pdf.

Udomsin S. and W. Rean-aree. 2016. Research and design biogas of the 2.5 kW electric power from Napier grass for household. Final report of project, Retrieved March 28, 2019 in the World Wide Web: http://ir.swu.ac.th/xmlui/bitstream/handle/123456789/5087/PRO2397.pdf?sequence=1.

Noikaw B., 2016. Napier grass: one of renewable energy from biomass. Bank of Thailand, Retrieved March 13, 2019 in the World Wide Web: https://www.bot.or.th/Thai/MonetaryPolicy/Southern/ReasearchPaper/napier_grass.pdf.

Department of alternative energy development and efficiency (Ministry of Energy, Thailand) 2013. Napier grass: green energy forum. Presentation report, Retrieved March 13, 2019 in the World Wide Web: http://webkc.dede.go.th/testmax/node/152.

Khezri R., Azlina W. and Tan H.B., 2016 An experimental investigation of syngas composition from small-scale biomass gasification. International of Journal of Biomass and Renewables 5: 6-13.

Jeenanurugk D., 2014. The feasibility study of investment on biomass power plant from Napier Pakchong 1 grass Amphoe Muak Lek Changwat Saraburi. Thesis, Kasetsart University, Bangkok, Thailand.

Kamutavanich W., 2015. A comparative study of power generation technologies suitable for Napier grass. Independent study, Thammasat University, Bangkok, Thailand.